Spn 647 fmi 5 detroit.

series 60 – spn 647/fmi 5 – single-speed fan (low-side digital output #3) fault Posted on October 9, 2020 by sam This fault code indicates that there is an open circuit. …Experience: Volvo/Mack Master Tech, Certified with Cummins, Eaton, GM, Hino, Detroit Diesel. Mike Mcmillan is online now. Get an Answer Continue. Share this conversation. See more. Related Medium and Heavy Trucks Questions. ... 2011 International trouble codes Spn 647 fmi 5 oc 4 Sa 0Spn 27 FMI 4 Oc 1 Sa 0Spn 2791 …403-05.pdf - SPN 677/FMI 5 -EPA07, SPN 677/FMI -EPA10, SPN 677/FMI 5 - GHG14 Subject: SPN 677/FMI 5 -EPA07, SPN 677/FMI -EPA10, SPN 677/FMI 5 - GHG14 Keywords: DD Platform, All Years, MCM Created Date: 4/22/2015 9:58:38 AM82.2 SPN 1072/FMI 5 This fault code indicates that the Jake Brake Stage 1 circuit failed open. 82.2.1 Open Circuit Check Check as follows: 1. Check for multiple codes. [a] If SPN 647/5, SPN 1071/5 and SPN 1072/5 are active repair the open in between pin 91 of the 120–pin MCM connector and the rear Jake Brake and fan control solenoids.

1. Wiring between the fan control solenoid and the 120-pin MCM connector. 2. Fan control solenoid failure. Detroit DD16 EPA10 (2010-13) Fault Code: SPN 647 FMI 5 (MCM) Fan Open Circuit October 21, 2022 Similar post Detroit DD13 EPA07 (2007-09) Fault Code: SPN 647 FMI 5 (MCM) Fan Open Circuit September 17, 2022 Similar post

SPN 647/FMI 5. This fault code indicates that there is an open circuit.‪ Open Circuit Check. Check as follows:‪ Check for multiple codes. If SPN 1071/5, SPN 1672/5, and SPN 647/5 are active, repair the open in between pin 91 of the 120–pin MCM connector and the fan and the Jake Brake solenoids. Refer to “57.3.2 Verify Repairs” .

7 SPN 709/FMI 5 - GHG17 Digital Output 3 16 Circuit Open Table 6. SPN 709/FMI 5 Description CPC Output 3 16 Open Circuit Monitored Parameter CPC Output 3/16 Typical Enabling Conditions Always Enabled Monitor Sequence None Execution Frequency Always Enabled Typical Duration Two Seconds Dash Lamps CEL Engine Reaction NonePACCAR PX-9 CM2350 (2013-17) Fault Code:3634 PID: SPN:5484 FMI:4 Engine Fan Clutch 2 Control Circuit – Voltage Below Normal or Shorted to Low Source DTC TRUCKS Rated 0 out of 5Detroit Diesel EPA 2010 and newer engines will often have active and inactive codes for the DEF system. There are a variety of Detroit DEF and SCR tests that exists, which we want to make you aware of. The following is a shortlist of possible codes that you could see: SPN 3361 FMI 0. SPN 3361 FMI 1. SPN 3361 FMI 3. SPN 3361 FMI …1. Turn the ignition OFF. 2. Disconnect the fan control solenoid connector. 3. Turn the ignition ON (key On, engine OFF). 4. Measure the voltage between pin 1 of the fan control solenoid connector and ground. [a] If the voltage is greater than 11.5 volts, repair the short to power between pin 1

Section 57 SPN 647. This SPN indicates a single-speed fan (low-side digital output #3) fault.‪ 57.1 SPN 647/FMI 3. 57.2 SPN 647/FMI 4. 57.3 SPN 647/FMI 5

• SPN 102/FMI 16, 18 • SPN 1636/FMI 2 • SPN 2630/FMI 2 • SPN 2659/FMI 0, 18 • SPN 3058/FMI 9 • SPN 3216/FMI 3, 4, 13 • SPN 3464/FMI 16, 18 • SPN 5312/FMI 7 a. Yes; diagnose the other fault codes first. b. No; Go to step 5. 2 SPN 3216/FMI 2 - GHG14 4 All information subject to change without notice.

SPN 84 - FMI 10 (Fault Code 242) SPN 647 - FMI 4 (Fault Code 245) Blog.Teknisi. Subscribe to receive free email updates: 0 Response to "SPN 98 - FMI 1 (Fault Code 253)" ... DETROIT Diesel Engines (36) Car Diagnostics (25) Manual Book and Parts Book (19) Competency Training (18) Setting Display (17) PLC Programming (15)SERIES 60 DDEC VI TROUBLESHOOTING GUIDE. 1.1 OVERVIEW. Detroit Diesel Corporation is the world leader in diesel engines and diesel engine electronics. DDC has made technological leaps in engine performance and fuel economy. Today, we build the most dependable electronically controlled diesel engine in the industry.5 SPN 3251/FMI 1 - EPA07. This diagnostic is typically Diesel Particulate Filter (DPF) Pressure Out of Range Low. This fault code sets when the pressure across the DPF is less than 1.5 kPa (0.2 psi) for more than 10 seconds. Table 4. SPN 3251/FMI 1 Description DPF Pressure Out of Range LowHi guys! The truck came with broken valves! After removing the cylinder head and replacing the valves and valves seats i had another issue! The problem was w...@DETROIT. Service Information Bulletin SUBJECT DATE SPN 4364 (ACM) (GHG17) June 2016 Additions, Revisions, or Updates Publication Number/ Title Platform Section Title Change GHG17 DD SPN 4364/FMI 17 - DDC-SVC-MAN-0191 Minor additions along with five new steps. Platform GHG17Jun 10, 2019 · SPN 647/FMI 5 This fault code indicates that there is an open circuit.‪ Section 58.3.1 Open Circuit Check Check as follows:‪ Check for multiple codes. If SPN 1071/5, SPN 1672/5, and SPN 647/5 are active, repair the open in between pin 91 of the 120–pin MCM connector and the fan and the Jake Brake solenoids. Refer to "58.3.1.1 Verify Repairs" . MasterTech Mike. Technician. Academic Honors Diploma. 286 satisfied customers. I have a 2015 Freightliner cascadia with a DD15 engine. I. I have a 2015 Freightliner cascadia with a DD15 engine. I have fault codes SPN 639 FMI 2, SPN 1548 FMI 5, SPN 516497 FMI 12 … read more.

63- 4 63.3 spn 647/fmi 5 ..... 63- 5 64 spn 651 64.1 spn 651/fmi 14 ... ddc-svc-man-0084 copyright 2010 detroit diesel corporation 3-5 3.2 epa07 turbocharger inlet air temperature sensor 3.2 epa07 turbocharger inlet air temperature sensor the motor control module ...SPN 647/FMI 5. This fault code indicates that there is an open circuit.‪ Section 57.3.1 Open Circuit Check. Check as follows:‪ Check for multiple codes. If SPN 1071/5, …Trucking Jobs in 30 seconds. Every month 400 people find a job with the help of TruckersReport.SPN 100/FMI 5 - GHG17 SPN 100/FMI 10 - GHG17 SPN 100/FMI 17 - GHG17 CPC - GHG17 DD Platform SPN 100/FMI 1 - GHG17 SPN 100/FMI 18 - GHG17 DDC-SVC-MAN-0193 MCM - GHG17 DD Platform MD SPN 100/FMI 0 - GHG17 Added note to diagnostic procedures. SPN 100/FMI 1 - GHG17 SPN 100/FMI 3 - GHG17 SPN 100/FMI 4 - GHG17 …15 nov 2018 ... fan and cable connections (J 2/4, J 2/7, J 2/18, J 2/40). SPN 647 FMI 5 ... Detroit Diesel · Deutz · Ditch Witch · Dodge · Dongfeng · Doosan ...250.1 SPN 1231/FMI 9 - EPA10 - GHG14. Aftertreatment Control Module Message Not Received or Has Stopped Arriving. SPN 1231/FMI 9. DescriptionThis Fault Code Sets when the Motor Control Module (MCM) Stops Receiving Messages from the Aftertreatment Control Module (ACM) Monitored ParameterACM Controller Area Network (CAN) Communication

1 5 28-13 SUBJECT DATE SPN 3246/FMI 0 - EPA10 - GHG14 May 2013 Additions, Revisions, or Updates Publication Number / Title Platform Section Title Change DDC-SVC-MAN-0084 EPA10/ GHG14 DD Platform SPN 3246/FMI 0 - EPA10 - GHG14 This is a new FMI for SPN 3246. 5 28-13 All information subject to change without notice. 34 SPN 3361/FMI 5 - GHG14 Diesel Exhaust Fluid System Circuit Failed Open Table 4. SPN 3361/FMI 5 Description Diesel Exhaust Fluid (DEF) System Open Circuit Detected Monitored Parameter DEF Dosing Unit Voltage Typical Enabling Conditions DEF Dosing enabled then disabled Monitor Sequence None Execution Frequency Continuous when enabling ...

SPN 3464 (MCM) (GHG14) August 2014 Additions, Revisions, or Updates DDC-SVC-MAN-0084Publication Number / Title GHG14 DDPlatform Section Title Change Platform SPN 3464/FMI 16 - GHG14 This is an updated section with new diagnostics including software level. SPN 3464/FMI 18 - GHG14 8 04-14 All information subject to change without notice. 3124 spn 3719 - soot level above normal 124.1 spn 3719/fmi 0, 15,16,or 31 ..... 124-3 125 spn 3798 - proportional valve bank 2 circuit 125.1 spn 3798/fmi 4 ..... 125-3 126 spn 3720 - ash level ...2 SPN 521049/FMI 31 - GHG17 DEF Inducement DEF Lamp Active Table 1. SPN 521049/FMI 31 Description This Code Sets When There is a Code Present for the Diesel Exhaust Fluid (DEF) Tank Level, DEF Dosing Unit, DEF Pump, NOx Sensors, Blocked DEF Line, DEF Quality, NOx Efficiency, Selective Catalyst Reduction (SCR) Harness and/or SCR Sensor.SPN 636/FMI 2. This fault indicates there is no match of camshaft and crankshaft signals.‪ Are there any other camshaft (SPN 723/FMI 3 or 4) or crankshaft (SPN 636/FMI 3 or 4) circuit faults active? Yes, repair circuit failure first, if the problem is still present after circuit repair, go to the next step. No, go to the next step.series 60 - spn 647/fmi 3 - single-speed fan (low-side digital output #3) fault This fault code indicates that there is a short to power. 58.1.1 Short to Power Check Check as follows: 1.… Series 60 Engine Cooling Fanseries 60 - spn 641/fmi 9 - smart remote actuator 5 (vgt) abnormal operation This code typically means the Smart Remote Actuator 5 is in Failsafe Mode, Motor Off. 57.3.1 Actuator Check Check as… Series 60 - SPN 641/FMI 14 - SMART REMOTE ACTUATOR 5 (VGT) ABNORMAL OPERATION

NOTE: SPN 520328 FMI 7 or SPN 520327 FMI 4 may also set as a result of this fault. 1. Connect DDDL/DDRS 7.08 SP2 or newer version. 2. Turn the ignition ON (key ON, engine OFF). 3. Check for multiple codes. a. If other faults are active, including SPN 4334/FMI 3, 4, or SPN 4374/FMI 3, 4, troubleshoot the other faults first. b.

7 SPN 709/FMI 5 - GHG17 Digital Output 3 16 Circuit Open Table 6. SPN 709/FMI 5 Description CPC Output 3 16 Open Circuit Monitored Parameter CPC Output 3/16 Typical Enabling Conditions Always Enabled Monitor Sequence None Execution Frequency Always Enabled Typical Duration Two Seconds Dash Lamps CEL Engine Reaction None

PACCAR PX-9 CM2350 (2013-17) Fault Code:3634 PID: SPN:5484 FMI:4 Engine Fan Clutch 2 Control Circuit – Voltage Below Normal or Shorted to Low Source DTC TRUCKS Rated 0 out of 5MasterTech Mike. Technician. Academic Honors Diploma. 286 satisfied customers. I have a 2015 Freightliner cascadia with a DD15 engine. I. I have a 2015 Freightliner cascadia with a DD15 engine. I have fault codes SPN 639 FMI 2, SPN 1548 FMI 5, SPN 516497 FMI 12 … read more.PID-168 1 Detroit Serie 60. ID-1 8 Wheel Sensor ABS Axle 1. ID-1 8 Wheel Sensor ABS Axle 1 Left Aug 08, 9:26 AM Aug 13, 12:59 PM Constant SID-4 5 Wheel Sensor ABS Axle 2 Right Aug 13, 9:46 AM Aug 13, … read more.Detroit DD13 GHG14 (2014-16) Fault Code: SPN 641 FMI 5 (MCM) Turbocharger Control Circuit Failed Open. NOTE: Please see the step by step troubleshooting procedures for …Trouble Code (DTC) list for SPN 3251 FMI 2, 3 and 4 (DPFDP/outlet pressure). Is EST DTC list free of SPN 3251 FMI 2, 3 and 4? Yes: Go to step 4 No: Repair SPN 3251 FMI 2, 3 and 4. After repairs are complete, retest for SPN 5397 FMI 31. StepAction Decision 4 Using terminal test kit, inspect connections at Diesel ParticulateFault Code 14: Invalid Shift Lever Voltage. J1587: MID 130 SID 18 FMI 2, 4, 5. MID 130 SID 19 FMI 2, 4, 5, 14. J1939: SA 3 SPN 751 FMI 2, 4, 5 ... 609–647 ohms. 2 ...Fault Code: 245. PID (P), SID (S): S033. SPN: 647. FMI: 4/4. Lamp: AMBER. SRT: REASON: Fan Control Circuit - Voltage Below Normal or Shorted to Low Source. Low signal voltage detected at the fan control circuit when commanded ON. EFFECT: The fan can possibly stay on continuously or NOT run at all.Page 144 [a] If the engine exhaust smoke emission appears normal, no further troubleshooting is required. Shut down the engine. [b] If the engine exhaust smoke is excessively black or gray, call the Detroit Diesel Customer Support Center (313-592-5800). Shut down the engine.PID-168 1 Detroit Serie 60. ID-1 8 Wheel Sensor ABS Axle 1. ID-1 8 Wheel Sensor ABS Axle 1 Left Aug 08, 9:26 AM Aug 13, 12:59 PM Constant SID-4 5 Wheel Sensor ABS Axle 2 Right Aug 13, 9:46 AM Aug 13, … read more.Typically with an open circuit fault, the fan will stay running constantly and not cycling. The open circuit fault is suggesting that moisture is inside the plug …

160.3 SPN 641/FMI 5 - EPA07 - EPA10 - GHG14. Turbocharger Control Circuit Failed Open. Show/Hide Checkboxes. Disconnect the wastegate control solenoid connector. Turn the ignition ON (key ON, engine OFF). Measure the voltage between pins 1 and 4 of the wastegate control solenoid connector. If the voltage is between 11 and 13 volts, Go to step 5.12. Install a test ACM. Is SPN 1761/FMI 3 still present? a. Yes; replace the DEF tank temperature/level sensor. Refer to section "Removal of the 13- and 23-Gallon Diesel Exhaust Fluid Tank Header Unit". Verify repair. b. No; replace the ACM. Verify repair. 2 SPN 1761/FMI 3 - GHG17 6 All information subject to change without notice.2 SPN 521052/FMI 31 - GHG17 DEF Inducement CEL Lamp Active Table 1. SPN 521052/FMI 31 Description This Code Sets When SPN 521050/FMI 31 has been Present for One Hour of Idle Time, the Vehicle has been Restarted or Six Gallons of Fuel has been Used. Monitored Parameter SCR and Diesel Particulate Filter (DPF) SensorsWorking on a 2008 Sterling truck with a MBE/Detroit OM 460 engine...When under heavy load it throws code SPN 2631, FMI 2. and derates the engine until it is restarted. ... -SPN 1072 FMI 4 -SPN 1127 FMI 18 -SPN 647 FMI 5 -SPN 4811 FMI 2 -SPN 4813 FMI 4 -SPN 1265 FMI 4 -SPN 3936 FMI 0 -SPN 1127 FMI 10 -SPN 1127 FMI 14 …Instagram:https://instagram. knoxville back pagesxhasetr1978 ford bronco for sale craigslistsam's club st cloud gas price Jun 6, 2019 · Section 8.6SPN 164/FMI 5. The fault condition is typically Rail Pressure Sensor circuit open or a stuck in range sensor.‪. Check as follows:‪. Check for multiple codes. If additional fault codes are present with 615/14, service the additional fault codes first. If only 615/14 is present go to the next step. mugshots journal starcraigslist dsm ia free stuff Make: Detroit Engine: DD15 GHG17 (2017 & Newer) PID: N/A SPN: 708 FMI: 5. Description: Digital Output 3 12 Circuit Open Troubleshooting: DESCRIPTION: CPC output 3 12 open circuit. MONITORED PARAMETER: CPC output 3/12. TYPICAL ENABLING CONDITIONS: Always enabled MONITOR SEQUENCE: None EXECUTION …82.2 SPN 1072/FMI 5 This fault code indicates that the Jake Brake Stage 1 circuit failed open. 82.2.1 Open Circuit Check Check as follows: 1. Check for multiple codes. [a] If SPN 647/5, SPN 1071/5 and SPN 1072/5 are active repair the open in between pin 91 of the 120–pin MCM connector and the rear Jake Brake and fan control solenoids. walgreens flu shots hours SPN 647 FMI 4 FAN CLUTCH CIRCUIT- voltage below normal or shorted to low source I found this from a previous poster DebbieMH (Lynn) published a thread a few weeks ago about getting an engine code SPN 1081 - FMI-19, and it being a "false code" produced by a communication problem between Cummins electronic monitoring system …Experience: Volvo/Mack Master Tech, Certified with Cummins, Eaton, GM, Hino, Detroit Diesel. Verified. Hello and thank you for using Just Answer. ... 2011 International trouble codes Spn 647 fmi 5 oc 4 Sa 0Spn 27 FMI 4 Oc 1 ... the firts thing they said abs module and have the next codes ACTIVE spn 3984--fmi 2--sa 33preactive …